Ciscomotors C-Max Manuel d'utilisateur

CiscomotorsCiscomotorsCiscomotorsCiscomotors CCCC----MaxMaxMaxMax SIMPLIFIED MAINTENANCE MANUAL All information in this publication is

Page 10 3.3 MAINTENANCE SCHEDULE FREQUENCY INSPECT REPLACE Before and after each use Every 50 hours All screw nuts, bolts correctly tigh

Page 11 4. STORAGE Extended storage such as for winter, requires that you take certain steps to reduce the effects of deterioration from not

Page 12 6. ASSEMBLY/DISASSEMBLY STARTER Figure 18 1. Remove 4 screws (Fig.18) 2. Remove the screw (Fig.20) for to arrive to the pulle

Page 13 7. REGULATION BELT TRANSMISSION The tension of belt must be done very carefully 1. Slightly little the 4 fix screws of br

Page 14 8. CARBURATION REGULATION Figure 35 1. Regulation min.throttle engine 2. Regulation gasoline/air min. (L) 3. Regulatio

Page 15 8. ELECTRICAL SCHEDULE Electric starter with recharge battery

Page 16 10. TROUBLESHOOTING 10.1 THE ENGINE DON’T START CHECK POSSIBLE CAUSES SOLUTION No fuel in tank Fill tank for

Page 17 10.3 EXESSIVE VIBRATIONS OF THE ENGINE CHECK POSSIBLE CAUSES SOLUTION Excessive wear, holder rubber Replace (Max 70 Sh) Sile

Page 18 11. TORQUE VALUES ENGINE ITEM Thread diam. x pitch Torque Kgf-m Cap screw propeller hub M6 M 6 x 1,0 1.2 Cap s

INDEX Page 2

Page 3 1. OPERATING INSTRUCTIONS 1.1 BASIC OPERATION

Page 4 1.2 START ENGINE WARNING • Never run the engine in an closed area. The exhaust contains poisonous carbon monoxide gas that can cause loss o

Page 5 Version manual starter without clutch: 1. To carry in a pressure the circuit of the gasoline, to help itself pressing the diagramm (F

Page 6 1.3 RUNNING-IN PROCEDURE Following proper break-in procedure helps censure that some of the most important and expensive components o

Page 7 2. SPECIFICATIONS 2.1 ENGINE INSTALLATION ON CHASSIS Picture 3 1. Support engine 2. Manual starter 3. Electric starter

Page 8 2.2 TECNICALS CHARACTERISTICS Motor C-MAX Type

Page 9 3. MAINTENANCE 3.1 GENERAL SERVICE INFORMATION: • Wear gloves and glances when you make the maintenance; • Do not perform maintenance w